Foxhunter Radar

AI24 Foxhunter Radar

Development

In the early 1960s, RRE (Radar Research Establishment) Great Malvern and Elliott began research into a new type of radar they called FMICW (Frequency Modulated Interrupted Continuous Wave), with possible application in two areas; AI (airborne interception) and AEW (airborne early warning). In a frequency modulated continuous wave (FMCW) radar a continuous wave is smoothly varied in frequency over time. The frequency of received radar signals is then compared with that being currently emitted in the receiver. The combination of the two waveforms gives frequency-triplets which can be decoded to give target range and range rate. However, as radar energy emission is continuous, it needs separate transmit and receive antennas which is not practical in airborne applications.

FMICW complicates this by periodically interrupting the waveform to allow a single antenna to both transmit and receive. This introduces additional complexities to the design over FMCW via PRF intervals and harmonics. However it seemed a method to allow good lookdown detection capability and be a promising alternative to the US AMTI solution used in the E-2C Hawkeye.

In 1963 studies started for a naval AEW aircraft which became the Blackburn P.139. By 1965, FMICW radar technology was looking very promising and the P.139 had settled on an FASS (fore-and-aft scanner system) radar with inverse-cassegrain antennas using FMICW. However, in 1965 the UK carrier fleet was axed and the P.139 consigned to history.

Work continued in Britain on FMICW despite these setbacks. In 1967 a prototype radar flew in a Canberra. A prototype of an FMICW AEW radar was under construction in 1971 but was cancelled on cost grounds, and also because the US was building its new E-3 AWACS with a High PRF Pulse Doppler radar, which worked on slightly different principles to the UK FMICW approach.

By 1967 Britain was formulating the Operation Requirement for the MRCA, and hit upon the idea of an air intercept variant to replace the Phantom in the air defence role. The Tornado ADV (Air Defence Variant) requirement was formulated as long ago as 1969. However, the ADV version was not considered a high priority in the early stages, as the RAF was only just receiving brand new F-4M Phantoms, and a replacement wouldn’t be needed until the early 1980s. Indeed, the contract for AI24 wasn’t signed until 1976, though Marconi had flown test hardware prior to this.
Foxhuntera.jpg
Foxhunter prototype on bench

Marconi-Elliott were given responsibility for developing the AI24 radar for the ADV (incidently, the “Foxhunter” name was never official; the designation for the radar was just AI24) with Ferranti supplying some components. Requirements for AI24 were ambitious. ADV was expected to intercept Soviet bombers and cruise missiles at extended distances, at high and low altitudes. Detection range for a typical bomber was to exceed 100 nautical miles (185km) and the radar was expected to track multiple targets simultaneously. Emphasis was placed on ECCM capabilities as the intended targets were assumed to use powerful ECM systems. Lookdown detection ranges were expected to be as great as possible.

In order to meet these tough requirements, Marconi-Elliott decided to base AI 24 on their longstanding work on FMICW radars, which had seemed to offer strong lookdown performance and long range detection, and, crucially, was thought to offer good resistance to ECM.

The US meanwhile had moved on from AMTI to modern pulse-Doppler radars. The F-14’s AWG-9 was a High PRF pulse Doppler radar with FM ranging for long range target detection. Marconi’s own FMICW concept was largely a version of the same concept, the distinguishing features of FMICW being extremely high PRFs, very high duty cycle (near 50%), and the use of a single range gate; that is, rather than dividing the interpulse receiving period into individual range cells corresponding to targets at different ranges and analysing them separately, a single sample was taken of the whole interpulse region. This integrated the returns (and hence clutter) from many range cells into a single range gate. The magnitude of the ground clutter is therefore typically high, 80-90dB above thermal noise, requiring an exceptionally good dynamic range signal processing chain, extremely low sidelobe levels and a very pure transmitted signal to allow successful target detection. However, it simplified the processing as only a single set of Doppler filters needed to be formed, rather than multiple filters for each range gate. Early FMICW radars used analogue processing; for AI24 Marconi used digital signal processing.

A fibreglass based, twist-cassegrain antenna was selected, for two main reasons. Firstly, very low sidelobe levels were thought to achievable, which helped in ECM resistance and was also important as outlined above for FMICW performance. Additionally, the resulting antenna was extremely lightweight (just 3lb!), which reduced inertia and allowed rapid scanning, which would be helpful in track-while-scan mode.
buccaneer.jpg
Buccaneer XX897, used to test Foxhunter

Following early trials of test radars in a Canberra from 1975, and from 1976 a Buccaneer (XX897) assigned to RRE, the first flight of a Foxhunter in a Tornado was made on 17 June 1981. The original forecast in-service date for the Foxhunter radar was 1982. By 1983, the “B” version was flying in Tornado ZA283, but production radars were still two years away.
The first batch of 18 Tornado F2s were delivered without radars, and had to be fitted with ballast in the nose to compensate for the weight of the missing radar. This lead to the now famous “Blue Circle radar” joke (Blue Circle being a British manufacturer of cement, and handily following the pattern of British radar designations like Blue Fox, Blue Vixen etc). Foxhunter did not enter service until 1985 and then only an interim standard version that didn’t meet requirements, despite a 63% increase in development costs.

Not all the problems were of Marconi’s making. Part of the problem was the lack of experience in fighter radars in Britain. The last indigenous fighter radar had been the Ferranti AI23 for the Lightning, but while Ferranti had built the US AWG-10 pulse-Doppler radar under license, Marconi had comparable recent experience to draw on. It was still expected to produce radar to roughly equal the AWG-9, the most powerful and expensive fighter radar in the world, at lower cost. Yet the actual contract was an old-fashioned “cost plus” contract where the government agreed to pay all costs plus a percentage profit, rather than a fixed price, which some industry observers feel contributed to the late service entry and problems encountered.

In some respects, the early Foxhunter was actually slightly inferior to the AWG-12 radar on the British F-4 Phantom II. No tail-chase programming was initially requested, and this had to be added later, as did close combat modes. A 20 target TWS capability was required, but was optimised for bomber raid assessment and targeting, not manoeuvring combat. Whilst it worked well in testing against drone targets, in service it proved unable to correctly track multiple targets making turns and moving in less predictable ways. Allegedly, it had problems with detecting lower RCS targets in clutter, and Hawks used in air training with the Tornado F3 were fitted with radar repeater pods.

Foxhunter-2.jpg
Production Foxhunter

Marconi and the UK government agreed a multi-year plan to bring Foxhunter up to an acceptable standard. By 1988, “Stage 1” radars were introduced into production which fully met the basic requirements of the RAF. These were to be followed by the definitive “Stage 2” radars, with new programmable digital processors. For the Gulf War in 1991, an emergency “Stage 1+” was introduced, to give some of the “Stage 2” capabilities to the “Stage 1” radar, but crucially this did not include the vital NCTR (Non Cooperative Target Recognition) mode as this feature required the new upgraded processors of "Stage 2”. The lack of NCTR relegated the F3 to a secondary air defence role well behind the front line. This was introduced with the “Stage 2G” in 1996, and further refined since then.

Since Stage 2 there have been continuous programmes of improvement for the Foxhunter, which are detailed later in the “Variants” section. The latest standard of AI24 radar supports the AIM-120 AMRAAM, and finally lives up to the original promise of this troubled radar design.
 
Last edited:
Re: Foxhunter Radar

Detailed Description

Foxhunter weighs about 300kg altogether, slightly more than half the weight of AWG-9 and slightly heavier than the APG-63.

Contrary to other reports, Foxhunter is primarily digital in design. Indeed, its adoption of digital signal processing was perhaps premature given the technology levels available, and was not until Stage 2 replaced the processors that it really lived up to expectations.

It uses two separate IF receivers; one for FMICW modes and one for Pulse modes, as the optimal characteristics of each mode were impossible to accommodate in a single unit. Pulse modes use SAW (Surface Acoustic Wave) compression.

FMICW modes use FM modulation of the waveform for ranging. The received signal is processed using digital signal processing techniques.

Processors are a mixture of hard wired, firmware microprocessor and digital programmable technology. The Frequency Analyser uses hard wired Schottky TTL and LSI circuits.

A high speed, wide dynamic range, A/D Converter takes the analogue signal from the FMICW IF (intermediate frequency) receiver and converts it to digital samples. The digital samples are analysed in the Frequency Analyser using FFT algorithms which vary depending on the period of FM ranging modulation.

A weighting process reduces the spreading caused by the short sampling period, followed by an automatic detection process. The detector uses a constant false alarm (CFAR) process which continually adjusts the detection threshold as a function of the combined clutter and receiver thermal noise levels. Signals exceeding this threshold level are passed to the range correlator which determines range by comparing the outputs from different phases of the FM waveform. The final stage is a plot extractor which produces a well defined and unique output of the range and range rate of each target.

Hyperboloid-Cassegrain.jpg

Twist Cassegrain antenna of the type used on Foxhunter. A fixed feed (A) emits polarised radar energy forwards. The radar hits a hyperboloid sub-dish (B), with embedded wires parallel to the plane of polarisation, which reflects the radar signal. It then hits the paraboloid main reflector (C) where the polarisation is twisted by 90 degrees by wires arranged at 45 degrees to the plane of polarisation. The radar signal then bounces forward again, but due to its changed polarity now passes straight through the sub-dish.
 
Last edited:
Re: Foxhunter Radar

Performance and Modes


Detection Ranges

(from Gruszczynski & Rybak, probably represents “Z” standard. Later models are said to have at least 10-15% greater detection ranges.)

185km vs a bomber target, head on engagement
130-140km vs a bomber target, tailchase engagement
120-130km vs a fighter target, head on engagement
75-90km vs a fighter target, tailchase engagement

Modes

Pulse Doppler Search / TWS


ADV-Target-Search.jpg
Target Search

ADV-TWS.jpg
Track-While-Scan

These are the primary radar modes, used for long range detection, tactical evaluation, and missile fire control. PRFs used are above 100Khz. In Search, contacts are drawn as vertical lines, with IFF friendlies drawn as crosses. The target selection marker is the -| |- shape. In TWS, each target is assigned a letter, and a line (vector) indicating target direction and ground speed. The WSO can get numeric information (including target height) on any tracked target by selecting it with the marker. Friendly targets are assigned numbers rather than letters. Target B is drawn reversed because it is currently outside the scan limits of the radar; the Memory Track feature will keep plotting the predicted path of the target (as a straight line in last known direction) to aid re-acquisition.

TWS mode can track up to 20 targets at once; if an additional track file is initiated, the radar weighs it against the existing targets and either discards it or deletes one of the existing targets.

Pilot and WSO can additionally select a Tactical Evaluation Display, which attempts to correlate all targets from radar, RWR, and datalink on a single display.

Pulse Doppler Angle Lock / CW Illumination

ADV-Skyflash.jpg
Angle Lock (Single Target Track)

HUD.jpg
HUD presentation of the same engagement

Angle Lock is a 4 channel Monopulse single target tracking mode (Sum, Azimuth Difference, Elevation Difference, and Double Difference channels). Single target tracking is necessary to engage a target with Sky Flash; it maintains CW illumination (separately selected) on the target during missile flight. On the CRT display, TRK A LOC indicates that target A is the locked on target. MRM A indicates Sky Flash (Medium Range Missile) is armed. Note that target B remains on the display, using the Memory Track feature, reversed out to indicate it is not currently being tracked by the radar. By plotting the predicted movement of the former TWS targets during the single target lockon phase, reacquisition of the targets after reverting to TWS mode should be made easier. The HUD picture shows the pilot’s HUD presentation of the same engagement; only the locked on target is shown, as a small circle with a vector indicating direction and speed. The solid dot aiming marker must be held inside the outer Allowable Steering Error circle.

Pulse Combat

Described as “rapid target lockon of visually sighted target”.

Pulse Angle Lock

Described as “fire control of gun, very close range angle”

Ground Mapping

Basic ground mapping for navigation, using pulse compression modulation
 
Last edited:
Variants

  • B initial “complete” version, flew in 1983.
  • W First production version, 70 built. Fitted to Batch 4 Blocks 8 + 9, Batch 5 Block 10. 44 “W” later upgraded to “Z” standard from 1988.
  • Z 80 built. Fitted to Batch 5 Block 11, Batch 6 Block 12. Supposed to be the 'final' version meeting requirements. Broadly met initial requirements, but not the revised requirements.
  • Stage 1 76 built from September 1988. Fitted from Batch 6 Block 13 to 15. Improved radar functions related to the aircraft's new F-18 style HOTAS (Hands On Throttle and Stick) controls, improved cooling (for Saudi ADV) and refined TWS and ECCM algorithms. HUD Search mode, activated by a HOTAS switch, scans the 20 deg field of view of the HUD and automatically locks on to any detected target. 124 “Z” radars were upgraded to Stage 1 software.
  • Stage 1+ was rushed through in 1991 for the Gulf War. Radar designation is AA, with revised software.
  • Stage 2 was intended to be the definitive Foxhunter, fully meeting the revised requirements of the RAF.
  • Stage 2G was introduced from 1996; includes NCTR (Non-Cooperative Target Recognition) technology. Radar designation is AB.
  • Stage 2G* upgraded the radar processors and software.
  • Stage 2H upgraded the radar processor and optimised software.
  • CSP (Capability Sustainment Programme) was signed 5 March 1996, providing for upgrades to 100 Tornado F3s to allow use of AIM-120 AMRAAM and ASRAAM missiles. Radar upgrades would allow multi-target engagement capability, and attempt to unify the fleet on a common radar standard. Other targets included reducing susceptibility to ECM and improved serviceability. CSP was implemented in two stages in order to deliver some operational advantages as soon as possible. First delivery was made in 1998, and both phases were scheduled to be completed by 2002. It did not include a mid-course update facility for the AIM-120 AMRAAM, due to technical difficulties.
  • AOP (AMRAAM Optimisation Programme) was signed on 8 June 2001, for the provision of a mid-course guidance capability for AMRAAM on Tornado F3 aircraft, initial IOC was end 2002, and the upgrade program was concluded by late 2004.
  • FSP (F3 Sustainment Programme) Signed in December 2004, FSP sets out to address a number of issues identified at the end of the AOP (AMRAAM Optimisation Programme). It includes integration of AIM-120C-5 and ASRAAM FOC2 and enhancement of the weapons systems capability, particularly the displays, through a number of radar computer and main computer software changes. In December 2005, a Tornado F3 fired two AIM-120C-5s at subsonic targets.

Sources

Jane’s Avionics
Jane’s Radar & Electronic Warfare
Jane’s Aircraft Upgrades
Hansard www.publications.parliament.uk
www.tornado-data.com
Flight International
Tornado ADV News Issues 2, 3, 7 (via www.tornado-data.com)
Press releases from Panavia, QinetiQ, BAe Systems
Aeroguide 21: Tornado ADV Linewrights, 1988
Glenn Ashley, Panavia Tornado in Action Squadron/Signal
Andy Evans, Panavia Tornado Crowood Press, 1999
J Gruszczynski, E.F. Rybak, Panavia Tornado, Lotnictwo Wojskowe, 2000 (Polish)
Bill Gunston, Modern Combat Aircraft 6: Panavia Tornado, Ian Allan 1985
Paul Jackson, Aircraft Illustrated Special: RAF Tornado, Ian Allan, 1987
Paul Jackson, ‘Panavia Tornado’ WAPJ Volume 3, Autumn 1990
John Lake, ‘Tornado Variant Briefing’ WAPJ Volume 31, Winter 1997
John Lake, Tornado: Multi-role Combat Aircraft, Midland Publishing, 2000
Doug Richardson, Modern Fighting Aircraft: Tornado, Salamander, 1986
 
Last edited:
Re: Foxhunter Radar

This is a preliminary version of an article to appear on my new avionics website. Comments and revisions welcome.
 
I guess once I have a few articles prepared. I've got more work on Tornado ADV avionics, and then Tornado IDS, then Su-27, MiG-29 and MiG-23 articles on the go too.
 
does the audi tornado have the same foxhounter radar and avionics as the UK, or are the saudi one downgraded??
 
Saudi Tornados were fitted with Type Z Foxhunters when they entered service. At a guess, they might have had some ECCM features removed.
 
Hello all iam new here i used to work on the tornado F3 adv as an avioincs tech.

Has anyone got a description of the functions of each LRU in the radar as i need info prior to an interview?

Thanx in advance bit of a longshot!
 
does anyone have any infomation of the LRUS i.e 1-12 inthe Foxhunter radar?

thanx!
 
Jus wondering if anyone here, knows the exact dimensions of the foxhunters radar dish....
 
Paul,

I just found this article and its fantastic, thank you for posting it! Prior to Options for Change it had been planned to MLU you the Tornado F3 in the early/mid 90s, it probably would have included JTIDS for the entire fleet (as opposed to just two squadrons as actually happened) and a multitude of radar upgrades that would have provided the type with virtually all the weapons capability that it was eventually given to it in a piecemeal fashion anyway to sustain the type until Typhoon arrived. It was referred to as a weapons system enhancement and the feasibility study was undertaken in 1990 but the project was dead by 1991.
 
Just found these pics I took of a Foxhunter radar at Manchester Museum Of Science and Industry.
 

Attachments

  • MOSI247.jpg
    MOSI247.jpg
    712.1 KB · Views: 227
  • MOSI248.jpg
    MOSI248.jpg
    890 KB · Views: 206
  • MOSI249.jpg
    MOSI249.jpg
    1 MB · Views: 181
  • MOSI250.jpg
    MOSI250.jpg
    613.5 KB · Views: 155
  • MOSI254.jpg
    MOSI254.jpg
    826.1 KB · Views: 176
flogger-23 said:
does the audi tornado have the same foxhounter radar and avionics as the UK, or are the saudi one downgraded??


I read this as "Italian-built Tornado ADV" at first, until I got to "Saudi" and realised it was a typo! ;D
 
David Gledhill's book Tornado F3 in Focus (Fonthill 2015) contains lots of information on the Tornado ADV avionics and nice pictures of the operating displays of the radar.
 
We old F-4 mafia were looking forward to the new technology that the "Foxhunter" was reportedly offering. It had a magic method of giving range in Pulse Doppler called Frequency Modulated Interrupted Continuous Wave (FMICW). It soon became known by a slightly different nomenclature, however - F*M*I*C*W*! Rumours had reached all of us about the state of the F2 radar, more specifically, the lack of one. In fact, stories in the aviation press had started to label the radar in the F2 as the "Blue Circle" (after Blue Circle Cement), due to the fact, that in order to maintain the aircraft's centre of gravity, it was thought that all the F2s were required to carry "ballast" where the radar should have been.

Whilst this was partially correct, most of the F2s were fitted with a radar, the" Y" List AI-24. This was a pre-production radar, which was fitted to the
aircraft to at least give the new crews an insight of what to expect! What we saw did not impress us very much. I would go as far as to say we were all shocked - if this was what we were going to get, then things needed to improve, a great deal. GEC Marconi made the AI-24; their previous adventure into Al radars had last been the Lightning AI-23 pulse radar!

There were other issues with the aircraft of course, but I will not dwell on those here. Suffice to say, action was instigated in order to attempt to rectify the situation. We were already due to get the first scheduled in-squadron version of the radar, the "W" List (I never did get an answer to why the "W" List came after the "Y" List). This duly came, and went, to be replaced by the "Z" List radar. This was to be the final version, which met all the requirements of the initial specification, supposedly! When it became clear that this was not the case, the Central Trials and Tactics Organisation, the predecessor to the Air Warfare Centre, instigated a trial, the purpose of which was to ascertain the deficiencies of the AI- 24, and associated systems. "Trial Bunbury" was conducted at RAF Coningsby. It involved a large number of sorties, consisting of relatively benign 1 v 1 intercepts, to Air Combat Manoeuvring sorties and large Composite Air Operations packages.

The results of this trial led directly to a "new" contract being signed with British Aerospace (BAE Systems as it is now known). This was known as the 395 FD Contract, meaning it was for £395 million and was the "Final Development". This would seek to improve the radar's capabilities in stages - first would come the Stage 1 variant, then the Stage 2, with improvements subsequently added to each, which were to meet the stated requirements. Nothing ever goes according to plan, and indeed this can be said of anything to do with the "Foxhunter". Over the following ten years other contracts were written, or hands shaken, leading to the Stage 2G*, Stage 2H and finally the Stage 3. The "G" stood for the incorporation of the modifications added during Operation GRANBY - the first Gulf War.

During this period, the F2 was reaching the end of its useful life. As the F3 started to trickle into service, the F2s were delivered to St Athan for storage, neverto be seen again - at least not totally intact. On one occasion, upon giving the F700 to the engineers at St Athan, we were told that the said F2 had 300 hours on it, but had consumed 9.9 Fl (Fl is Fatigue Index, w ith an aircraft usually having a total lifespan of 100 Fl). We pretended to be shocked, but really had to laugh when he informed us that a GR1 had just been delivered for upgrade - it had 1000 hours on the clock, and had used 4.5 Fl. Need I say any more?!

Anyway, I digress. Now operating the mighty F3, there was nothing stopping us - oh, hold on, the radar! To say that the OC o f the F3 Operational Evaluation Unit (OEU) at the time was a genius would be an understatement. The debt the RAF and F3 community owes to him is immense.

Under his leadership, the OEU was able to start a programme of trials, that were, eventually, able to guide industry and the MOD Procurement Executive, (which was the predecessor to the Defence Procurement Agency, and then the Defence Equipment and Support Organisation) into making the appropriate decisions and modifications required. An excellent working relationship was established with GEC Marconi and British Aerospace, with a permanent detachment of personnel from these companies established at the OEU.

Over a number of years, personnel came and went. In fact, Ian Ansell, aka "Ferret", came and went a number of times. Ferret worked for GEC at the time and is a legend within the F3 radar community, and rightly so. Along with the then Gp Capt Development, he was responsible for kick-starting the "Foxhunter" recovery. On my arrival at the OEU I was briefed by the OC that "if I saw Ferret plugged into the side of an F3 with his Psion computer, I was to give him a kick in the butt, as he was probably changing the functionality of the Radar Data Processor, or something else nefarious". Over the years, the OEU had many dedicated aircrew, all worked extremely hard to fix a number of "issues", and help to make a "silk purse out of a sow's ear".

There is no doubt that the groundcrew, specifically the avionics specialists, the "fairies", played a significant part in the "Foxhunter" story. Their dedication in fixing the vagaries of the radar were appreciated by all those aircrew that came back to base declaring "ZululO "(the serviceability brevity code for "radar unserviceable"). Although, I suspect, that some aircrews'debriefs were viewed w ith suspicion, this loyal ban'd of fairies would nod sagely, and endeavour to push "**** uphill", in order to give the next wave a serviceable beast!

story ends, some 26 years after the RAF took delivery o f the first "Foxhunter" radar. It has seen several iterations, culminating in the Stage 3 variant. There have been frustrations along the way. Ultimately, however, those that have had the privilege to operate the "Foxhunter", know that, if handled in the right manner, it gave tremendous service. Today's radars, w ith all the new modern Micro Mechanical Electro Systems and other technologies available, should be streets ahead of the"Foxhunter", however, when it worked, it could give many of these systems a run for their money.

At the end of its life, when operated efficiently, the "Foxhunter" was capable of holding its own amongst other fighters, operating modern Active Electronically Scanned Array/Phased-Array radars, whilst supporting active air-to-air missiles, in a high threat environment - as its last visit to Exercise Red Flag ably demonstrated. Will it be remembered as a "classic"? I doubt it, but it will certainly be remembered.

Sqn Ldr Colin "Wiki" Wills
Source: Justin Reuter Tornado F3 - 25 Years of Air Defence
 
Last edited:
View: https://www.reddit.com/r/WarplanePorn/comments/rr5pim/nostalgia_alert_an_infographic_of_soviet_vs_nato/?ref=share&ref_source=embed&utm_content=media&utm_medium=post_embed&utm_name=5a4232c169d042e8bb9e6fb092b5d0b2&utm_source=embedly&utm_term=rr5pim


I spoke with a USAF pilot who did an exchange with the German Air Force when they had Mig-29s. He had a lot of time in the Fulcrum and apparently Foxhunter was very deadly (to fight against) in a BVR engagement. The Mig of course was obviously dominate in visual range. This was presumably in the later 90s. I think as said above when it worked right it was great.
 

Attachments

  • 11FFD32F-6C83-4947-B9A0-3717DDF1EFBC.jpeg
    11FFD32F-6C83-4947-B9A0-3717DDF1EFBC.jpeg
    198.1 KB · Views: 55
Last edited:

Similar threads

Back
Top Bottom